Worn suspension — usually drop links, anti-roll bar bushes, top mounts, or wishbone bushes. All are routine wear items on UK roads.
Here's a quick, honest answer from a working UK mechanic — what causes it, what it costs to fix, and what to do next.
The usual suspects
Anti-roll bar drop links (£40–£100 fitted) are the most common cause. Wishbone bushes, strut top mounts, and worn shock absorbers can also knock. A garage on a ramp can spot the play in minutes.
How to test yourself
Park on level ground, push down hard on each corner and let go. The car should rebound once. More bounces = worn shocks. Listen for clunks as you push.
When to act
Knocks alone are not dangerous, but worn shocks lengthen braking distances by up to 20%. Most UK MOT testers fail vehicles with excessive play in suspension joints.
Can I drive on it? — Short term yes, but get it inspected — broken drop links can damage the anti-roll bar and degrade handling.
Why does my car knock only when cold? — Bushes stiffen in cold weather; small play becomes audible until the rubber warms up.
More detail on: Why does my car knock when going over bumps?
The short answer above covers the usual case. Below is the extra detail a UK driver normally needs to act on it — how to narrow the fault down, what it should cost, and when it is worth paying a garage rather than carrying on. This is general guidance from a working mechanic, not a substitute for someone putting your own car on a ramp.
Pin down when the noise happens
Noises get misdiagnosed because nobody narrows them down properly. Work through it methodically: does it change with road speed or engine speed? Does it appear only under braking, only on turns one way, only when cold, or only over bumps? A rumble that rises with road speed and disappears when you load the opposite wheel on a roundabout is a wheel bearing. A squeal that vanishes the moment you touch the brake pedal is usually the pad wear indicator. A knock over bumps at low speed is suspension, not drivetrain.
What it usually is not
Most drivers arrive convinced a noise is the gearbox or the engine internals, and most of the time it is something on the outside of the car that costs a fraction of what they feared — a heat shield, a worn drop link, a dry CV joint or a stone trapped in a brake shield. Have the cheap and common causes eliminated before you authorise anything that involves removing a gearbox.
What Bob would check first
Start with the cheap, common and visible: fluid levels and their condition, tyre pressures and wear pattern, battery voltage and terminal condition, and every connector and vacuum pipe in the area of the fault. A surprising share of electrical gremlins are a corroded earth or a chafed loom, and a surprising share of running faults are an air leak downstream of the sensor doing the complaining. Only after that does anything get unbolted.
When it is worth going to a main dealer
Three situations justify main-dealer money: an open safety recall (free), a live manufacturer warranty or goodwill claim, and coding or programming work that needs manufacturer-level software. Everything else — servicing, brakes, suspension, clutches, cambelts, diagnostics — an experienced independent will do to the same standard for a good deal less, and using an independent does not invalidate your warranty under UK block exemption rules as long as the correct parts and schedule are used.
Safe to keep driving?
Treat anything affecting brakes, steering, tyres, seat belts or visibility as stop-now, no matter how well the car appears to be driving. Overheating and low oil pressure are also stop-now: the damage curve on both is measured in minutes, not miles. Most other faults will let you drive gently to a garage, but if the car is in limp mode, losing fluid, or the fault changes how it steers or stops, get it recovered instead. Recovery is cheaper than a tow plus a new engine.
Get an answer on your own car
If you want this looked at properly for your exact vehicle, send the details and Bob will write back — make, model, engine, mileage, when the fault happens and any codes you have. You get a written reply from a qualified UK mechanic with 32 years on the tools, not a chatbot, and your money back if he cannot help.
Ask a mechanic about your car · Free MOT history check · Free recall check · Fault code library