Volvo P0430

Bank 2 cat efficiency on Volvo T6/B6 — XC60/XC90 inline-6 turbo cat aging or oil-burn from worn PCV.

Volvo P0430 — Bank 2 cat efficiency on Volvo T6/B6 — XC60/XC90 inline-6 turbo cat aging or oil-burn from worn PCV. Typical UK independent garage cost: £240–£1800.

What actually causes P0430 on a Volvo

Volvo T6 P0430 from 120k+ is normally a worn cat, but always rule out PCV oil-mist contaminating the rear brick. Bank 2 on the inline-6 is the cyl 4-6 cat. Volvo OEM cats are eye-watering; quality aftermarket E-marked alternatives last well.

Volvo engines that log P0430

• T6 3.0 turbo (XC90/S80)
• B6 mild-hybrid (XC60)
• D5 twin-turbo diesel

How we diagnose P0430 on a Volvo

1. Read rear O2 switching live
2. Check oil consumption pattern
3. Inspect PCV diaphragm
4. Smoke-test exhaust upstream

The common misdiagnosis to avoid

Don't fit a new cat without addressing PCV oil burn — the new cat will cook within 30k.

Volvo P0430 repair cost in the UK

Expect £240–£1800 including parts and labour at an independent garage. Main-dealer quotes on Volvo are usually higher for the same job, and the spread exists because the cheap cause and the expensive cause throw the same code — pay for the diagnosis before you pay for parts.

Bob's workshop tip

Volvo T6 P0430 + heavy oil use = PCV first, then cat. Fix the cause.

Codes usually seen alongside P0430 on Volvo

• P0420
• P2096

Symptoms drivers report with P0430

• MIL comes on after a motorway run then stays lit — no drivability change
• Slight sulphur/rotten-egg smell on hard acceleration
• MPG drop of 1–3 mpg you wouldn't notice unless you track it
• Fails emissions/lambda snapshot at MOT despite passing tailpipe CO
• Bank 2 short-term fuel trim slightly richer than bank 1 at cruise

Repairs that clear P0430

• Same diagnostic as P0420 but bank 2 side
• Replace bank 2 rear lambda first as trial
• Confirm with lambda graphing before cat replacement

For the generic, all-makes explanation of this code — meaning, every known cause and UK cost bands — see our P0430 guide.

Reading P0430 on a Volvo properly

A generic reader will show P0430 and nothing else. What matters is the freeze-frame data stored with it — engine speed, load, coolant temperature and fuel trims at the moment the fault was logged — plus whether any other module on the Volvo has logged something at the same time. Codes rarely arrive alone, and the order they were stored in usually points at which one is the cause and which are the consequences.

Clearing P0430 without fixing it

Erasing the code resets the Volvo's readiness monitors as well as the light. The fault returns on the next drive cycle if the cause is still there, and in the meantime the incomplete monitors can stop the car passing an emissions check. After a genuine repair, the car is driven until the relevant monitor completes before it is handed back.

Bob's Mechanical Repairs is an independent garage in Birnam, Dunkeld, Perthshire, with 32 years of Bob's experience on the tools. If P0430 is showing on your Volvo, bring any scan results with you — we will read the live data ourselves, confirm which cause it actually is, and price the repair before any work starts.